-
- دوشنبه تا شنبه: 10:00 - 16:00 / یکشنبه تعطیل است
The flotation results indicated that, when sodium oleate (NaOl) was used as the collector, HEDP displayed an outstanding depression effect on the dolomite flotation, whereas it had only a slight ...
به خواندن ادامه دهید
The reverse flotation of the iron ore with etheramine collector is significantly impacted when the iron-bearing silicates and the kaolinite are present in the …
به خواندن ادامه دهید
This was achieved through a reverse flotation process. The impact of flotation pH, collector dosage, and type on the selectivity and recovery of calcite and dolomite was assessed. The results revealed that FA-based collectors outperformed other collectors by providing higher quality concentrates with less CFA losses.
به خواندن ادامه دهید
Iron ore flotation can be performed in two technical routes: direct flotation of iron oxides and reverse flotation of gangue minerals with depression of iron oxides.
به خواندن ادامه دهید
Research regarding iron ore flotation began in 1931, demonstrating that reverse cationic flotation is a very efficient method for beneficiating oxidised iron ores. This method can also be applied ...
به خواندن ادامه دهید
Flotation tests proved that PNFS was able to depress dolomite effectively, but hardly influenced the flotation of apatite, which also exhibited high selectivity for raw head ores. FTIR, zeta potential, adsorption capacity and XPS results proved that -SO 3 - groups of PNFS complexed with Ca and Mg atoms on dolomite by means of single layer ...
به خواندن ادامه دهید
The significant applications of iron ore flotation are reviewed along with an abbreviated discussion on theory and reagent use. Problems or conditions which have militated against a widespread adoption of the flotation process by the iron ore industry, are discussed in contextual relationship to supply, economics, alternatives, and process limitations.
به خواندن ادامه دهید
1. Introduction. Flotation is a selective process for separating minerals from each other based on particle hydrophobicity. The flotation separation efficiency depends on the recoveries of the mineral species by both true flotation and entrainment (Cilek, 2009, Neethling and Cilliers, 2009, Wang et al., 2015).Both chemical variables and …
به خواندن ادامه دهید
The batch flotation tests are performed using an MVTAT flotation cell built at the Technische Universität Bergakademie Freiberg. In order to minimize the impact of froth recovery, the flotation test was developed by using shallow froth levels and frequent froth removal (Dobby and Savassi, 2005).Fig. 1 provides an overview of the flotation …
به خواندن ادامه دهید
Micro-flotation results indicated that the addition of P (AA-AMPS) could achieve the efficient separation of apatite from dolomite at pH 8.5 by selectively depressing the dolomite flotation, in ...
به خواندن ادامه دهید
At low pH (approximately pH 5), the iron dissolves from the mineral, forming a hydrophobic surface deficient in iron and rich in sulfur, thus resulting in a higher flotation rate (Equation (1)). At high pH (pH > 9), the iron form a hydroxide on the surface, which, being a hydrophilic species, decreases the flotation rate (Equation (2)).
به خواندن ادامه دهید
1. Introduction. Mining activities consume billions of m 3 of water annually. The water withdrawn by mining industries could achieve 17 m 3 per ton of processed ore while the water consumption required in processing varies between 0.34–6.27 m 3, according to data from 359 industries reports [1].Seeing that the world iron ore …
به خواندن ادامه دهید
In this review, studies on the interactive effect among minerals on the flotation of iron ores, magnesite ores, and scheelite ores are summarized, and the …
به خواندن ادامه دهید
Sodium silicate is one of the main depressants against calcite and fluorite in the scheelite flotation industry. In the first part of this article, the authors acidified sodium silicate (AWG) with ...
به خواندن ادامه دهید
The components of a flotation system are (figure 1): Cell: A container that contains an impeller and is competent to retain the solids in suspension. It also provides aeration for frequent air bubble- particle collision. Feed: The pipe that is used to supply materials i.e. flotation pulp to the cell. Flotation pulp: A mixture of solids (to be ...
به خواندن ادامه دهید
The collector is the most important reagent used in the iron ore flotation process. The function of the collector reagent is to promote affinity between mineral particles and air bubbles by formation of a water …
به خواندن ادامه دهید
This paper investigates the reverse flotation of iron ore in a laboratory mechanical, oscillating grid (OGC) and pneumatic flotation cell. The main objectives are to investigate the recovery of ...
به خواندن ادامه دهید
With the depleting reserves of high-grade iron ore in the world, froth flotation has become increasingly important to process intermediate- and low-grade iron ore in an attempt to meet the rapidly growing demand on the international market. In over half a century's practice in the iron ore industry, froth flotation has been established as an …
به خواندن ادامه دهید
The aim of this paper is to provide a well-detailed, well-referenced source for the current status of iron ore flotation, and thus provide a useful guide to its future development and to further ...
به خواندن ادامه دهید
Iron ore handling, which may account for 20–50% of the total delivered cost of raw materials, covers the processes of transportation, storage, feeding, and washing of the ore en route to or during its various stages of treatment in the mill.. Since the physical state of iron ores in situ may range from friable, or even sandy materials, to monolithic …
به خواندن ادامه دهید
It is well documented that flotation has high economic viability for the beneficiation of valuable minerals when their main ore bodies contain magnesium (Mg) carbonates such as dolomite and magnesite. Flotation separation of Mg carbonates from their associated valuable minerals (AVMs) presents several challenges, and Mg …
به خواندن ادامه دهید
The flotation beneficiation of apatite for phosphate production is challenging for finely disseminated sedimentary ores rich in carbonates. Similarities in surface properties of the semi-soluble salt-type carbonate and phosphate calcium minerals combined with fine intergrowth are the main reasons for poor grade and low recoveries. …
به خواندن ادامه دهید
In the flotation of carbonate-hosted Pb-Zn ore, the separation of dolomite is critical to obtain high-quality zinc concentrate. In this study, fine-grained dolomite was found to be more floatable than coarse-grained dolomite, and it was the main cause of magnesium contamination. Entrainment dominated the flotation of fine-grained dolomite.
به خواندن ادامه دهید
Fig. 2 illustrates the iron ore beneficiation process, particularly magnetic separation, resulting in the generation of inevitable tailings. Due to the characteristics of iron ores and the conditions during beneficiation, it is inevitable that approximately 2.5–3 tons of IOTs are generated for every 1 ton of iron ore concentrate produced [7].In 2019, …
به خواندن ادامه دهید
A combination of two stage of hydrocyclones and froth flotation tests at mechanical cells were performed with high alumina iron ore slimes targeting to recover …
به خواندن ادامه دهید
In the flotation of iron ores, the difference in flotation rates between iron oxides and gangue minerals needs to be enlarged, which can be achieved by changing …
به خواندن ادامه دهید
Starch is among several biopolymers used in reverse flotation of iron ores. It renders the mineral surface more hydrophilic and thus is not susceptible to attaching an air bubble or join in the ...
به خواندن ادامه دهید
In the field of mineral processing, the successful flotation of target minerals requires sufficient liberation through grinding. The aim of this paper is to compare and evaluate the performance of ball versus short cylindrical media for comminution of dolomite by point and line contact, respectively. The results of the grinding experiments indicate …
به خواندن ادامه دهید
Araujo et al. (2020) studied the flotation performance of the amidoamine (Flotinor 5530) in the reverse rougher flotation of iron bearing slimes assisted by high intensity conditioning (HIC) using ...
به خواندن ادامه دهید
Starch is widely used as the depressant in iron ore flotation. The present paper attempts to highlight different facets of starch as an iron ore depressant. It reviews the important research papers that discuss the origin and chemistry of starch, starch-iron oxide interaction mechanism, and the application of different types of starches and ...
به خواندن ادامه دهید