-
- دوشنبه تا شنبه: 10:00 - 16:00 / یکشنبه تعطیل است
Currently beneficiation of hematite ores is conducted using either direct flotation (hematite flotation) or indirect flotation (quartz flotation) tech-niques depending upon the nature …
به خواندن ادامه دهید
This paper provided a new case to adjust the flotation performance by developing a collector and predicting its froth stability. ... Hematite reverse flotation pulp is seriously deteriorated by ...
به خواندن ادامه دهید
In this study, a new green and efficient inhibitor NaHA was used in hematite reverse cationic flotation system with DDA as collector. The results of micro-flotation showed that a appropriate concentration of NaHA could selectively inhibit hematite and realized the effective separation of quartz and hematite.
به خواندن ادامه دهید
The flotation performance of DTDAB was studied by microbubble flotation based on reverse flotation desilication system of hematite. Moreover, the collapse performance of was also studied. The flotation mechanism of DTDAB was studied by contact angle, AFM, FT-IR, XPS, and density functional theory (DFT) calculation. 2. …
به خواندن ادامه دهید
The effects of siderite on reverse flotation of hematite were investigated using micro flotation, adsorption tests, and Fourier transform infrared spectroscopy. The flotation results show that interactions between siderite and quartz are the main reasons that siderite significantly influences the floatability. The interactions are attributed to …
به خواندن ادامه دهید
Parra Alvarez, Natalia, "REVERSE CATIONIC FLOTATION OF HEMATITE", Open Access Dissertation, Michigan Technological University, 2022. …
به خواندن ادامه دهید
Following the interaction of STA with hematite, new peaks emerged at 3735.15 cm −1 and 2929.60 cm −1, ... entitled "Application and mechanism of an efficient hydrophobic flocculant CPAM in the flocculation reverse flotation of hematite and microfine-grained chlorite". No conflict of interest exits in the submission of this …
به خواندن ادامه دهید
The new amidoamine collector was able to promote a selective flotation of quartz from hematite without a depressant agent, such as starch. Therefore, this reagent …
به خواندن ادامه دهید
Low grade deposits containing specular hematite (Fe2 O3) as the major iron mineral as low as 25% Fe can be treated with "Sub-A" Flotation to produce concentrates that average better than 62% Fe with less than 9% SiO2 and with a high recovery.
به خواندن ادامه دهید
Hematite reverse flotation pulp is seriously deteriorated by chlorite due to the dissolution of chemical components (e.g., metal ions) on its surface.
به خواندن ادامه دهید
Flotation of mixed minerals (hematite and quartz mixture in various ratios) indicated that LGB could enhance separation efficiency (hematite recovery > 88%). Outcomes of the surface wettability indicated that even in the presence of the collector (dodecylamine), LBG decreased the hematite work of adhesion and had a slight effect on quartz.
به خواندن ادامه دهید
The aim of this paper is to provide a well-detailed, well-referenced source for the current status of iron ore flotation, and thus provide a useful guide to its future development and to further ...
به خواندن ادامه دهید
Micro-flotation results showed that curdlan was used as an effective depressant for quartz-hematite reverse flotation separation. In artificial mixed ore tests, …
به خواندن ادامه دهید
Anionic reverse flotation of hematite has been widely used in hematite beneficiation as it can effectively weaken the influence of slime ... W. Yin, C. Sun, B. Yang, J. Yao, H. Li, C. Li, H. Kim, New insights into the flotation response of brucite and serpentine of different conditioning time: Surface dissolution behavior, Int. J. Min. Met ...
به خواندن ادامه دهید
Bench Flotation experiments in duplicate were performed in a 3 L Barker flotation machine. Agitation time with starch depressant was 5 min. Conditioning time with the collector was 2 min. Stirring with reagents was conducted directly in the flotation cell, with a pulp density of 33 wt% and the pH was maintained at a value varying between 9.5 …
به خواندن ادامه دهید
The depression of hematite in the reverse flotation system of oleate-starch-hematite was investigated at the atomic level by atomic force microscopy (AFM) combined with density functional theory ...
به خواندن ادامه دهید
Furthermore, according to the above procedures, at the site, the flotation temperature of the flotation circuit can be input in the range from 20 to 45 °C, and the flotation reagent system can be ...
به خواندن ادامه دهید
The flotation recovery of flocculated hematite has been measured. The recovery is almost constant and low in the acidic pH range, and increases above neutral …
به خواندن ادامه دهید
In this paper, we report the benefits of partial replacement of amine collectors with a frother in reverse cationic flotation of hematite. Surface tension and batch flotation experimental results indicated for the first time that replacing Flotigam EDA, an etheramine collector by more than 10% improved the flotation performance in both …
به خواندن ادامه دهید
The cation reverse flotation is a widely used method in improving the grade of iron ore concentrate, but hematite depressant is the key. In this work, the flotation behavior of hematite and quartz using the complex of Fe(III) and xanthan gum (Fe(III)-XG) as depressant was investigated via micro-flotation tests.
به خواندن ادامه دهید
List of Figures Figure 3.1: Simplified flotation-scavenger circuit at Plant A .....42 Figure 3.2: Fine and low-grade hematite ore beneficiation process flowsheet (Mariani and
به خواندن ادامه دهید
The traditional hematite depressant starch has the disadvantages of poor solubility and high viscosity. In this study, a novel hematite depressant, pullulan, with better performance and flotation effect than starch was found. The structure, molecular weight and viscosity of pullulan were determined for its characterization. The results of flotation …
به خواندن ادامه دهید
However, starch could depress the flotation of hematite. Flotation recovery of 98.10% for quartz could be achieved, when N23 concentration was 43.33 mg/L and starch concentration was 16.67 mg/L at ...
به خواندن ادامه دهید
In hematite or quartz flotation using DDA as a collector, the active ion C 12 H 28 N + would be enriched on the surface of hematite and quartz, forming a layer of positively charged surface, meanwhile the counter ions (CH 3 COO −) were distributed at the interface, forming a surface double electric layer. When the liquid film became …
به خواندن ادامه دهید
The flotation recovery of quartz and hematite was analyzed by investigating the impact of the molar ratio of DDA to SLS under specified conditions of pH 7.2±0.2 and a collector dosage of 30 mg/L (Fig. 1).Initially, without the addition of SLS, both hematite and quartz displayed similar recovery, suggesting a lack of separation efficiency between the two …
به خواندن ادامه دهید
To understand why hematite of different genesis behave diversely in flotation systems, this study assesses the flotation response at pH 5 of bulk …
به خواندن ادامه دهید
In this study, ultrasonic treatment was introduced to enhance the depressive performance of starch in the reverse flotation separation of fine hematite from quartz. It was found that after ultrasonic treatment, starch was not only able to impart a higher surface wettability of hematite, but also bet …
به خواندن ادامه دهید
A new technique, called magnetic seeding flotation, was also proposed to aggregate weak magnetic mineral particles with magnetite particles, which leads to more …
به خواندن ادامه دهید
In this work, a complete beneficiation technical route combining physical and chemical methods, namely a roasting-flotation-leaching scheme, is proposed to produce a qualified grade Ti-concentrate from altered Vanadium titanomagnetite (VTM) ore. Based on the character of the ore sample, it is recommended to recover the Ti-bearing minerals, …
به خواندن ادامه دهید
The new findings of the present study well revealed the dissolution of microfine hematite and the pH effects on the hematite flotation, as well as the adsorption characteristics of oleate species ...
به خواندن ادامه دهید